Despite a slight improvement in 2010 and 2011, UK aggregates markets are going lower in the current year.
Last year, the production of sand and gravel and crushed rock was around 160 million tonnes. In 2012, production is likely to fall to around 145 million tonnes.
This is a level not seen since the early 1960s, says industry marketing consultant,
While it had been forecast that public sector demand would fall, the private sector has not taken up the slack. Aggregates companies have been affected in 2012 by lower consumer confidence in the housing market, and developers unwilling to start speculative projects due to the economic situation.
These are some of the conclusions of the annual BDS Marketing Research report, Estimated Outputs of Pits, Quarries and Marine Wharves in Great Britain. This shows company market shares at a local, regional and national basis. As well as market shares, the report lists sites that have opened or closed and changes in company ownership. It also includes an independent three-year forecast for the industry.
The survey is used by existing companies to compare their market share with their competitors, equipment suppliers and others considering investment in the industry.
Markets remain patchy. Sand and gravel demand in the south-east has been rising, due to increased markets for ready-mixed concrete. However, crushed rock producers in Scotland have faced a difficult time, with 2011 volumes much lower than the previous year.
BDS expects the aggregates market to go lower by around 10% during 2012. It is forecasting a bottoming out of volumes in 2013, with some hesitant recovery in the second half of next year.
The top five companies are completed by
The current supply situation will change when the proposed joint venture is formed between Tarmac and Lafarge, says the report. A total of seven aggregates sites need to be disposed of to meet the requirements of competition authorities, together with Tarmac’s interest in
BDS has identified ten quarries have been acquired over the past year. In addition, it lists 44 quarries that have closed. When the recession first started, it was the major companies that shut operations. More recently, BDS has identified that it is primarily the smaller companies that have been closing quarries.
For further details of the report contact Julian Clapp at BDS on Tel: +44 (0) 1761 433035; Email: %$Linker:
The report on quarry outputs has been published at the same time as equivalent reports on ready-mixed concrete, asphalt and concrete products, says BDS.
